| NEWS |
 |
|
|
 Technical Articles
/ Technical Articles' List
/
Back to Poultry Industry
|
| |
Vitamin Levels in Breeder Diets |
  (19 Sent)
Who saw this article? New!
Author: Steve Leeson - Department of Animal and Poultry Science/University of Guelph - OMAFRA Newsletters
Publication date: 04/08/2008
Hubbard breeder hens are capable of peak egg production around 86% under commercial conditions, with sustained peaks over 80% for 12 weeks. This high egg output is only possible with superior management and nutrition, part of which is a well-fortified high energy diet. These high persistent peaks also mean that we have to supply adequate vitamins in the feed, not only for the hens very active stage of reproduction, but also to ensure optimum hatchability and chick quality. Unfortunately, what we consider to be optimum vitamin needs of the breeder are often questioned as being too high and too expensive, when in reality it is low-vitamin levels in the feed that are ultimately the "most-expensive" scenario for the bottom-line of the breeder or integrated broiler operation.
Diets for adult breeder hens probably contain the highest level of supplemental vitamins of any feed manufactured at a commercial feed mill. These vitamins are required for the normal function of most physiological processes in the body, and for the breeder hen we have the added need for adequate carry-over into the eggs. Unfortunately a deficiency of any one vitamin can cause a dramatic decline in egg production and hatchability, and yet the levels recommended by Hubbard and other breeders are often questioned as being too high, and therefore too costly. We usually meet the breeders' requirements for vitamins by adding all as synthetic sources. The regular feed ingredients, such as corn, soybean meal and meat meal, all contain "natural" sources of vitamins and in some situations could theoretically contain enough to meet the breeders' needs.
However the concentration of vitamins contained in corn will, for example, be affected by seed variety, growing conditions, harvesting conditions and storage conditions. Likewise the vitamins in meat meal will vary greatly depending upon the animal components used and the time and temperature of cooking and drying during processing. Obviously these ingredients come with no guarantees of vitamin levels, and bioavailable concentrations are expected to vary 200-300%. In addition to this inherent variability is the effect that factors, such as natural plant toxins and mycotoxins, can have on vitamin availability. For example, recent research data showed that the effects of a certain mycotoxin could be largely overcome by adding more thiamine, a B-vitamin, to the diet.
On this basis it is perhaps not too surprising that we do not rely on regular feed ingredients to supply vitamins, and consequently our vitamin premix is designed to supply all necessary vitamins for the bird. However this still does not answer the question of "why such high levels of vitamins in breeder feeds." The starting point used in developing vitamin requirements, is the NRC values which are updated each 6-8 years. These NRC values are absolute requirement values for individual vitamins, and most often reflect the level of vitamin needed to prevent deficiency symptoms.
In feeding breeders we want not only to prevent signs of vitamin deficiency, but also to ensure good egg production, hatchability and early chick vitality. This superior performance will only be achieved by feeding much higher levels of vitamins as part of a balanced nutritional program.
Another reason for higher vitamin fortifications relative to NRC (1994) is the loss in potency of vitamins that occur between feed manufacture and consumption by the bird. Different vitamins are susceptible to various stresses to varying degrees, but as a generalization it can be stated that the major causes of loss of vitamin potency are storage time, storage temperature, and storage humidity of the premix before mixing, and of the feed after mixing. Another major loss of vitamins occurs if they are premixed with minerals and stored for any length of time prior to incorportion in feed. Also conditions within the premix and feed can cause loss of potency. For example, some vitamins are acidic whereas others break-down under acidic conditions. Finally to really cause problems to vitamin stability, we sometimes pellet feed, and here the temperature and humidity can cause vitamin breakdown.
The manufactures of vitamins are able to tell us factors which affect potency of their vitamins, and so with this knowledge, coupled with anticipated field conditions, we can project necessary safety factors to ensure optimum breeder performance.
The next question is how much does it cost to add these higher levels of vitamins, and are they worth it? BASF, a major producer of pure vitamins, recently conducted a survey of breeder operations in the USA and, as anticipated, found a range of vitamin levels being used. This industry data covered 62 broiler companies and represents about 90% of the industry. Table 1 shows the highest and lowest vitamin levels being used, and these are compared to NRC (1994). There is about a 100% difference between the top 25% and bottom 25% of reported levels for vitamin fortification. Table 1 also shows the cost of obtaining these individual vitamin levels, and the total cost per tonne of mixed feed.
Table 1. Breeder vitamin levels and costs
* = BASF Technical Bulletin #KC9305
Obviously the bottom line is how well do breeders perform based on high vs low-industry values. We do not have this data, but we can see that the higher vitamin levels cost us about 10¢ more per breeder, which in most markets is equivalent to 0.5 chicks per breeder. Considering that a number of the low-industry vitamin levels (Table 2) are even less than NRC (1994) we can be sure that this will affect performance, and from our experience, this will be much more than 0.5 chicks per breeder. Marginal vitamin levels can easily result in loss of 2-5 chicks per breeder, which is 4-10x the cost of the extra vitamins in the feed.
Our recommendation is, therefore, to feed adequate levels in the feed, because this ensures optimum delivery of vitamin to the breeder and the developing embryo. With these extra levels of vitamins in the feed, there should be no need to use supplemental vitamins in the water, except in situations of environmental or disease stress when feed intake is not optimal, or there is evidence of enteritis.
If vitamin levels are to be adjusted according to local conditions, then which ones are most likely to influence feed cost? Table 2 is a repeat of the industry high-level breeder vitamin recommendations, but in this situation they are listed according to contribution to cost of the premix. This data shows vitamin E, biotin and vitamin A to be the most expensive, and together make up over 50% of the cost of the vitamin premix. These three vitamins should, therefore, receive most attention when additions to, or deletions from premixes, are contemplated based upon knowledge of specific needs within a feeding program.
Table 2. Vitamin recommendations ranked by $ cost/tonne feed
|
Vitamin |
$/tonne feed |
% contribution
to premix cost |
| Vitamin E |
1.08 |
23.7 |
| Biotin |
0.77 |
16.9 |
| Vitamin A |
0.68 |
14.9 |
| Riboflavin |
0.53 |
11.5 |
| Pantothenic Acid |
0.38 |
8.3 |
| Pyridoxine |
0.31 |
6.8 |
| Niacin |
0.27 |
5.9 |
| Vitamin K3 |
0.13 |
2.9 |
| Folic Acid |
0.13 |
2.9 |
| Thiamine |
0.11 |
2.4 |
| Vitamin B12 |
0.09 |
2.0 |
| Vitamin D3 |
0.08 |
1.8 |
| Total |
$4.56 |
100.0 |
Vitamins are expensive, and together the premix represents about 2-3% of the cost of breeder feed. However the effects of deficient or marginal levels in breeder feed can be far greater than the 10¢ per breeder to be potentially saved by feeding at the low vs high end of current industry standards.
Author: Steve Leeson - Department of Animal and Poultry Science/University of Guelph - OMAFRA Newsletters
Publication date: 04/08/2008
(19 Sent)
Who saw this article? New!
 DISCUSSIONS ON THIS ISSUE.
 
| 04/10/2008 |
 |
|
Abideen Busari
- Great Britain |
|
|
I always appreciate good articles. This is surely one of them. I would say to the writer "thank you". | Answer Checked by Engormix.com  |
|
![]()
| 05/17/2008 |
|
|
|
|
Dear Sir,
An excellent and practical article. Congratulation for such article.
These type of articles are always appreciated as these can be applied on the flocks to get maximum results.
Thanks and regards.
Dr. Munawar Ali | | Answer Checked by Engormix.com |
|
![]()
|
|
ENGOREART AVG 20080706
|
| |
|
| |
Related Products |
 |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
 |
Biovet S.A. (Spain) |
COLUMVITAL
DESCRIPTION
COLUMVITAL is a vitamin complex with a quick long term effect.
TECHNICAL PROPERTIES
COLUMVITAL is a vitamin complex with ...
|
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
| |
Technical Articles |
|
| |
Sugar Syrup - A High Energy Feed Vis A Vis Animal Production
Feeding of livestock is a scientific task to make all the nutrients available for maintenance, production, growth and reproduction ...
Sanitation, Cleaning, and Disinfecting Poultry Facilities
Diseases and infections have always been a major concern to the poultry industry. Fortunately, microbial contamination can be prev ...
Understanding and Control of Gangrenous Dermatitis in Poultry Houses
DescriptionGangrenous dermatitis (GD) sometimes seems to occur almost spontaneously in birds 4-8 weeks of age. GD is also known as ...
New Concepts on the Horizon: Phytogenics in Poultry Production
Modern poultry and egg production is facing several challenges. Growing demand for poultry products and rising prices for raw ma ...
Brooding Chickens and Quail
Poultry and gamebird producers realize that chicks must be kept warm or brooded during the first weeks of life. Surprisingly, impr ...
Feed Passage in Broilers: A Complex Problem
"Feed passage," or, more accurately, the passage of undigested feed in the feces of broilers, continues to be reported in broiler ...
Poultry Meat Industry: Capons
What is a capon?Walking through the supermarket, it is often possible to find capons for sale. While it is obvious from the shape ...
Reducing Contamination of Hatching Eggs
Poor hatching egg sanitation can be a major cause in loss of hatchability and chick quality. Every effort should be made to ensure ...
Leg Problems in Broilers and Turkeys
Leg problems can occur in fast-growing strains of broilers and turkeys. These disorders are not unique to small flocks; they also ...
A Comparison Between Broilers Pastured in a Day Range System and Broilers Raised Intensively in the Gauteng Province, South Africa
Alternative poultry production, particularly pasture-based production, offers opportunities for producers interested in boosting i ...
|
 See all...
| | | | | Related Forums | | | | Article: Hatchability Problem Analysis
News: Using machines to monitor hen welfare and reduce egg breakage
Article: Hatching Egg Storage - How It Affects Embryo Survival
Article: Egg Production and Egg Specific Gravity in Laying Hens fed Reduced Phosphorus Diets Supplemented with Phytase
Article: Vitamin Levels in Breeder Diets
Article: Limiting Ovarian Development to Maximize Chick Production in Broiler Breeders
Article: Manipulating the immune system of layers and breeders: novel applications of mannan oligosaccharides
News: Small Flock Management: Preventing Hens From Eating Eggs
News: Chick sexing: Laying hens could produce only female chicks
Article: Breeder nutrition fundamentals in any poultry operation: recent developments in North Carolina
News: Poultry Management: Hot hens, more healthy
Article: Performance of Laying Hens fed a Corn-Sunflower Meal Diet Supplemented with Enzymes
Article: Hatchery-Breeder and Information Systems Educational Programs
Article: Broiler Performance From Cull Eggs
News: China's Artificial Eggs Spotlighted in Korea
|
|
