| NEWS |
 |
|
|
 Technical Articles
/ Technical Articles' List
/
Back to Poultry Industry
|
| |
Broiler Performance From Cull Eggs |
  (5 Sent)
Who saw this article? New!
Author: Gary D. Butcher, DVM, Ph.D and Amir H. Nilipour, Ph.D - Institute of Food and Agricultural Sciences, University of Florida
In a commercial broiler integration, the objective is to provide the best quality hatching eggs that produce the greatest number of quality chicks per hen housed. A properly managed hen can produce more than 180 eggs, which potentially can result in approximately 600 pounds of broiler meat. However, there exists great variation in the amount of meat produced per hen among integrations. Much of this difference can be traced back to how the eggs were managed during collection, storage, and incubation. The production goals of an integration can be achieved when basic concepts of optimum fertile egg selection and grading, plus common sense management, are considered.
What Is an Optimum Fertile Egg?
In the fertile egg industry, optimum fertile eggs are described in general terms as those with high percent hatch rates that produce high quality, good sized chicks. However, to be of practical value, this definition needs to be expanded to include the production cost per chick and pound of meat, in relation to market demand for poultry meat and fertile eggs. Actually, the profit and net income can be increased when the largest number of eggs can be incubated per hen housed. Increases can be achieved, in some cases, even with a lower average chick weight and percent hatchability. Obtaining high percent hatches with heavy chicks might look good on paper, but it may adversely affect cost of production when egg selection is too stringent, especially when fertile eggs are in short supply.
What Percent of Fertile Eggs Are Culls?
Depending on a company's situation, there can be considerable variation in egg culling. For example, if there is a strong demand for fertile eggs, as was experienced during the worldwide Myeloid Leikosis problem in heavy breeders, the focus must be on hatching the maximum number of eggs. At a commercial poultry integration, evaluation of results from more than 85 million eggs collected showed that under normal field conditions, the percent of cull fertile eggs should not exceed 4.0% during a 40-week production cycle. Table 1 shows the percent of the various categories for cull eggs during the four year period of the study.
These data are for normal conditions. However, if the market demands more fertile eggs and level of management at the breeder and broiler farms is excellent, less restrictive egg selection could be practiced. The 4% total cull eggs can be reduced to 2.5 to 3.0%. This can be achieved by decreasing the number of cracked eggs, by saving the mildly deformed and porous eggs, and by reducing minimum egg weights for incubation.
Table 1. Categorizing cull eggs
|
Category of cull egg |
% |
|
Cracks/Broken |
1.70 |
|
Double Yolk |
0.70 |
|
Pee Wee |
0.70 |
|
Dirty |
0.40 |
|
Deformed |
0.25 |
|
Porous |
0.25 |
|
Total |
4.00 |
Hatchability of Cull Eggs
These studies have demostrated that many fertile eggs classified as culls can produce quality broilers, even though they have a reduced percent hatch. Use of these eggs is an efficient and practical way to increase the number of eggs and chicks produced per hen housed. Table 2 shows the results of more than 13,000 under-grade broiler fertile eggs that were incubated at the Poultry Integration Grupo Melo S.A. in Panama. Clearly, many fertile eggs that would have been discarded have the potential to hatch.
Table 2. Hatchability of undergrade eggs.
|
Egg Type |
% Hatch |
|
Small |
60.76 |
|
Deformed |
52.32 |
|
Large |
45.86 |
|
Porous |
31.61 |
As demonstrated in Table 2, with good husbandry, one to 2% more fertile eggs can be incubated when eggs are needed. Thus, 97-98% of the eggs laid may be used. Incubating eggs normally classified as culls would reduce the percent hatchability to some degree, but calculations of the costs to produce fertile eggs must be considered, especially when fertile eggs are in short supply. In addition, these eggs might have had even a higher percent hatchability if stored only 1-3 days. In the trials described in this paper, eggs were stored between 3-7 days to accumulate sufficient eggs for the experiment.
Broiler Performance from Under-Grade Eggs
Chicks hatched from eggs classified as deformed, porous or small are the same as those from regular eggs, except that chicks from smaller eggs are smaller. In two separate studies, chicks hatched from fertile cull eggs were raised in an experimental farm to 49 days of age. The objective was to determine the final broiler performance parameters, even though the percent hatch was lower. Tables 3 through 6 illustrate that resulting broiler performance was competitive with eggs classified as normal controls.
Table 3. Female Broiler Performance--Trial 1
|
Parameter |
Control |
Small |
Deformed |
Porous |
| BW (gr) |
2182 |
2052 |
2256 |
2160 |
| Gr/day |
44.60 |
41.88 |
46.08 |
44.08 |
|
Conversion |
1.905 |
1.999 |
2.038 |
1.93 |
| % Mortality |
3.64 |
0.00 |
2.63 |
0.00 |
| Index |
225 |
209 |
220 |
228 |
| Cost/lb vs control (cents) |
0.00 |
1.44 |
1.28 |
1.1 |
In trial 1 (Tables 3 & 4), it was interesting that chicks hatched from deformed and porous eggs had comparable body weights to the control group at 49 days of age.
Table 4. Male Broiler Performance--Trial 1
|
Parameter |
Control |
Small |
Deformed |
Porous |
| BW (gr) |
2526 |
2423 |
2689 |
2642 |
| Gr/day |
51.55 |
49.45 |
54.87 |
53.92 |
|
Conversion |
1.919 |
2.01 |
1.966 |
1.871 |
| % Mortality |
3.64 |
3.77 |
7.14 |
10.00 |
| Index |
259 |
237 |
259 |
259 |
| Cost/lb vs control (cents) |
0.00 |
1.46 |
0.43 |
0.86 |
In trial 2 (Tables 5 & 6), the same or better body weights were obtained for the broilers hatched from deformed eggs, followed by porous and small eggs. In both trials the cost to produce a pound of broiler meat was higher when cull fertile eggs were used. Increased production costs were less in males as compared to females for all 3 cull egg categories. However, these cost differences can be offset when there are higher meat prices such as when fertile eggs are in short supply.
Table 5. Female Broiler Performance--Trial 2
|
Parameter |
Control |
Small |
Deformed |
Porous |
| BW (gr) |
2129 |
2026 |
2146 |
2127 |
| Gr/day |
43.45 |
41.35 |
43.79 |
43.42 |
|
Conversion |
1.853 |
2.086 |
1.912 |
1.981 |
| % Mortality |
0.00 |
0.00 |
1.82 |
0.00 |
| Index |
234 |
198 |
225 |
219 |
| Cost/lb vs control (cents) |
0.00 |
3.08 |
0.78 |
1.46 |
Table 6. Male Broiler Performance--Trial 2
|
Parameter |
Control |
Small |
Deformed |
Porous |
| BW (gr) |
2532 |
2472 |
2509 |
2376 |
| Gr/day |
51.67 |
50.45 |
51.21 |
48.49 |
| Conversion |
1.854 |
1.843 |
1.855 |
1.857 |
| % Mortality |
3.64 |
3.64 |
5.45 |
5.00 |
| Index |
269 |
264 |
261 |
248 |
| Cost/lb vs control (cents) |
0.00 |
0.12 |
0.36 |
0.84 |
Chick Size Varies
During the 40-week broiler breeder production cycle, egg size normally varies from 45 to 72 grams, primarily depending on breeder age. Egg size has a direct impact on chick weight. Table 7 provides average chick body weights obtained in relation to breeder ages. More than ¼ of the chicks produced during the peak of egg production, from breeders at 25-35 weeks of age, were less than 40 grams. Size variation can not be ignored. These chicks need extra attention to be as efficient and productive as the heavier chicks.
Table 7. Breeder age vs chick weight
|
Breeder Age (wk) |
Chick Weight (gr) |
|
25-35 |
39.7 |
|
36-45 |
43.0 |
|
46-55 |
44.5 |
|
56-65 |
45.7 |
Extra Care for Small Chicks
It must be emphasized that chicks from small eggs (less than 50 grams) have lower body weights (30-35 grams) and thus need extra attention when being transported to the farm and brooded. Small eggs should be collected and incubated separately. Following hatch, do not sex and mix with other regular size chicks. The small chicks should be sent to your best broiler farms, where the farm manager knows how to take care of these fragile, delicate animals and will provide special attention. These chicks need a couple extra days of brooding and additional vitamin supplementation. They should be marketed a couple of days later to reach the required body weight.
Proper Training
Many so-called "unfit fertile eggs" can be used, especially at times when a high demand for broiler fertile eggs and meat exists. When there is a fertile egg shortage, each cull egg merits reevaluation before it is declared unfit. The individuals responsible for classifying fertile eggs must be properly trained. They must know the standards and requirements for each egg category before pronouncing an egg unfit and culling. If increases in the number of cracked eggs, contaminated shells, and other flaws are seen, it must be recorded and reported to the respective farm manager to permit investigation and resolution of the problem. In many hatcheries visited, it has been observed that when the eggs arrive at the hatchery, the egg grader eliminates additional eggs, adding to the total of eggs eliminated. The egg graders at the breeder farms and hatchery must be in constant communication with the hatchery manager, and know what is going on in the fertile egg market. Eggs unnecessarily eliminated increase production costs and reduce the company's profit margin.
Footnotes
1. This document is VM125, one of a series of the Animal Science Department, Florida Cooperative Extension Service, Institute of Food and Agricultural Sciences, University of Florida. Original publication date April 29, 2002. Visit the EDIS Web Site.
2. Gary D. Butcher, extension veterinarian, University of Florida College of Veterinary Medicine, Gainesville, FL
Amir H. Nilipour, PhD, Director of Investigation and Quality Assurance, Grupo Melo, S.A., Panama, Republic of Panama
Author: Gary D. Butcher, DVM, Ph.D and Amir H. Nilipour, Ph.D - Institute of Food and Agricultural Sciences, University of Florida
(5 Sent)
Who saw this article? New!
 DISCUSSIONS ON THIS ISSUE.
 
| 03/13/2008 |
 |
|
Meer Lutfar Rahman
- Bangladesh |
|
Most helpful for the producers to optimise their production.
Thanks to the writer for this valuable research work.
Lutfar Rahman | Answer Checked by Engormix.com  |
|
![]()
| 03/13/2008 |
|
|
Abideen Busari
- Great Britain |
|
|
This is a very viable article. I use this opportunity to thank the writer for a job well done. As a feedmill manufacturer, and at the same time a farmer, this will (in no small way) improve my performance in Nigeria [West Africa]. | | Answer Checked by Engormix.com |
|
![]()
| 03/13/2008 |
|
|
kadi mr
Medecin Veterinaire/avi -first
Oum el Bouaghi - Algeria |
|
|
Un vrai travail de prof je remercie les auteurs:: un vrai chef-doeuvre. | | Answer Checked by Engormix.com |
|
![]()
| 03/16/2008 |
|
|
|
|
Excellent work.
Dr Sushanth Rai
India | | Answer Checked by Engormix.com |
|
![]()
|
|
ENGOREART AVG 20080511
|
| |
|
Usted necesita actualizar su Flash Player
| |  | | |
Usted necesita actualizar su Flash Player
| | |
Usted necesita actualizar su Flash Player
| |  | | |
Usted necesita actualizar su Flash Player
| |  | |  | |
|
| |
Related Products |
 |
| |
 |
Laboratorio Avimex (Mexico) |
Broni-mex*
(freeze dried)
REG. SAGAR B-0258-007
CODE 1202: 1,000 DOSES. 1222: 5,000 DOSES. 1232: 10,000 DOSES
DESCRIPTION
Lyophylized live vaccine against i...
|
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
|
| |
| |
| |
Technical Articles |
|
| |
The Most Important Ingredient: Water
Water is the most important nutrient for poultry. Unfortunately it is very much neglected by most poultry farmers in Asian countri ...
Intestinal Welfare
The intestinal welfare is a crucial parameter in animal production, changes in the welfare cause disbiosis (bacterial enteri ...
The most crucial period of a chick’s life - brooding
Brooding is the most crucial, critical and decisive period in a breeder chick’s life. Especially the first two weeks. This period ...
How much MYCOFIX® do I have to add to be SAFE???
Last November, one of Argentina’s largest table egg producers conducted a trial using Mycofix® Select in the diet of laying hens a ...
Limiting Ovarian Development to Maximize Chick Production in Broiler Breeders
There are several important instances in the management of broiler breeders where "more" is not "better". In simple terms, "more f ...
Emu Production
Emus are native to Australia. Commercial production there and in the United States is a very recent development. The first emu pro ...
Vitamin Levels in Breeder Diets
Hubbard breeder hens are capable of peak egg production around 86% under commercial conditions, with sustained peaks over 80% for ...
Eye Disorders of Poultry
Eye disorders are not generally prevalent in poultry on a flock basis. However, as birds rely heavily on their sense of sight to c ...
Feed Flavoring for Poultry
Do you believe that adding a flavoring agent to your broiler or layer feed will improve performance? Your answer is probably no, o ...
Calcium in Laying Rations: How to Sample Feed and Interpret Analysis
The purpose of this fact sheet is to demonstrate how to sample laying hen rations and interpret the calcium levels found in the fe ...
|
 See all...
| | | | | Related Forums | | | | News: Probiotic growth promoter for broilers approved by EU
News: Cannibalism in Birds: Prevention and Treatment
Article: Hatchability Problem Analysis
Article: Single stage incubation is the most natural choice
Article: Chick length & Organ development
Article: Good brooding conditions for the best starting of the chicks
Article: Broiler Performance From Cull Eggs
Article: Bird Flu: Biosecurity Recommendations for Commercial Poultry Flocks
Article: Limiting Ovarian Development to Maximize Chick Production in Broiler Breeders
Article: The most crucial period of a chick’s life - brooding
News: Chicks: Importance on the First Seven Days to Promote Weight Gain
News: Using machines to monitor hen welfare and reduce egg breakage
Article: Egg Production and Egg Specific Gravity in Laying Hens fed Reduced Phosphorus Diets Supplemented with Phytase
News: Bird Flu in Canada: Poultry Industry Will Help Farm
Article: Hatching Egg Storage - How It Affects Embryo Survival
|
|
